Drip Irrigation On-lot Sewage Disposal System
Pennsylvania has approved the use of drip irrigation as an alternate wastewater disposal method for on-lot sewage. The drip irrigation system was developed and is designed for sites with restrictive soil conditions, where the site’s limiting zone is within 20 to 26 inches of the soil surface or deeper.
Components of the Drip Irrigation System
The drip irrigation system has several components: a septic tank, a hydraulic unit pump tank, a hydraulic unit, and a special drip irrigation system buried within a few inches of the soil surface. Each of these components will be described below. An overall schematic showing the major components of a drip irrigation system is shown in Figure 1.
Figure 1. Schematic of a drip irrigation system.
Treatment or Septic Tank
The raw wastewater flowing from your home is delivered to a two-chamber septic tank, where the solids are separated from the liquid and the organic material is anaerobically decomposed before being passed on to the Hydraulic Unit Pump Tank.
Hydraulic Unit Pump Tank
The wastewater flowing from the septic tank is piped to and collected in a single-chamber tank known as the hydraulic unit pump tank. The collected wastewater is timed dosed to the drip irrigation distribution system.
Before the wastewater is piped to the drip irrigation absorption area, it must first pass through a disk filter to remove all remaining waste particles that might clog the drip irrigation emitters. In addition to final disk filtration, the hydraulic unit also serves as a switching unit that alternates the flow of wastewater to one of two drip irrigation zones. The hydraulic unit also receives flush return wastewater from the drip irrigation zones and transfers this flush water to the septic tank (Figure 1).
Drip Irrigation Absorption System
As final disposal, the wastewater is dosed to two or more drip irrigation zones. Each drip irrigation zone consists of a length of supply pipe that carries the wastewater from the hydraulic unit to the drip irrigation lateral and a return pipe that collects undischarged wastewater and returns it to the hydraulic unit. Connecting the supply pipe to the return pipe are two lengths of small-diameter (usually 0.5-in) drip irrigation lateral, which contains small devices, known as emitters, that meter the wastewater flowing in the drip irrigation lateral slowly into the soil. Each zone contains two laterals and each emitter discharges 0.61 gallons of wastewater per hour. The emitters are spaced at 2-foot intervals along the drip irrigation lateral. The length of each lateral is determined by the total system flow rate and the soil’s hydraulic characteristics as defined by a licensed soil scientist who must evaluate the soil. The supply, return, and laterals are shown schematically in Figure 2 for a two zone system.
The drip tubing must be installed so that there is always at least 18 inches between the limiting zone and the emitter tubing. The tubing may be installed to a maximum depth of 12 inches, but is usually installed at a depth of about 6 inches.
Figure 2. Schematic of drip irrigation zones.
The drip irrigation on-lot sewage disposal system was created as an alternative to requiring an elevated sand mound on some sites with limiting zones as close to the soil surface as 24 inches. The primary advantage of the drip irrigation system is that no large mound of soil is required because the drip laterals are inserted into the top 6 to 12 inches of soil. The disadvantage of the drip irrigation system is that you will need a large dose tank after the septic tank to accommodate the timed dose delivery of wastewater to the drip absorption area. The hydraulic unit is an additional cost, and regular maintenance is required.
For additional assistance contact your local Sewage Enforcement Officer or County Extension Educator.
Pennsylvania Association of Sewage Enforcement Officers (PASEO)
4902 Carlisle pike #268
Mechanicsburg, PA 17050
Pennsylvania Septage Management Association (PSMA)
Bethlehem, PA 18016
Department of Agricultural and Biological Engineering
246 Agricultural Engineering Building
University Park, PA 16802
TitleDrip Irrigation On-lot Sewage Disposal System
This publication is available in alternative media on request.